Warmland PS45 Classic Series A Owner's Manual download pdf (Page 17)

PELLET STOVES 17 PS45 CLASSIC 151211-24

Cleaning the Combustion Blower:

To clean the combustion blower, unplug the stove, remove

the left cabinet side. Loosen but do not remove the six screws

(Fig.#18) with an 1/4” nut driver or socket. Rotate the motor

counter-clockwise. The motor can now be pulled from the fan

housing. The cooling fan and main blade can be vacuumed

once the motor is removed. Before reinstalling, vacuum out the

blower housing and the  ue gas passages leading to and from

the combustion blower. Clean the inner surface of the Proof of

Fire Switch located on the Blower housing. When reinstalling

the motor, check the gasket between the motor and the fan

housing, a new gasket may need to be installed if damaged.

Place the motor back on the fan housing (motor down) and rotate

clockwise to lock the  ange, hand tighten the six screws.

Fig. #18

1/4"hex head screws

Fig. #19

Cleaning the Convection Blower:

To clean the convection blower, remove the right cabinet side

(see previous page). Disconnect the stove power cord from the

electrical outlet. Using a 3/8” wrench, remove the two bolts (Fig

#19) securing the blower to the blower duct. Slide the blower

out the side towards you disengaging it from the blower duct.

A vacuum can be used to remove any dust accumulation on

the blower’s blades or inside the blower duct. Caution should

be used not to damage the blower’s blades during cleaning.

To reinstall the blower, slide the blower back into the retaining

lip and install the screws.

Door Removal

CAUTION: Do not open the Firebox door when the stove is

hot or operating.

To remove the door, rotate the door handle clockwise to release,

and swing the door open. Lift the front door up and off the hinges.

To reinstall the door, repeat the steps in reverse order.

Back Grill Removal

To remove the back grill, loosen the three screws securing the

grill to the chassis. The back can now be pulled up and off of

the stove. Installation is the reverse.

REMOVE

1 2 ... 12 13 14 15 16 17 18 19 20 21 22 23 24

No comments

Warmland PS45 Classic Series A Owner's Manual Page 17